DOI: 10.1002/eej.20249. Thermal behavior of small lithium‐ion secondary battery during rapid charge and discharge cycles

Thermal behavior of small lithium‐ion secondary battery during rapid charge and discharge cycles

10.1002/eej.20249

Crossref journal-article

Wiley

Electrical Engineering in Japan (311)

Abstract

AbstractThe secondary batteries for an electric vehicle (EV) generate much heat during rapid charge and discharge cycles above the rated condition, when the EV starts quickly consuming the battery power and stops suddenly recovering the inertia energy. During rapid charge and discharge cycles, the cell temperature rises significantly and may exceed the allowable temperature. We calculated the temperature rise of a small lithium‐ion secondary battery during rapid charge and discharge cycles using our battery thermal behavior model, and confirmed its validity during discharge cycle at current smaller than the discharge rate of 1C. The heat source factors were measured by the methods described in our previous study, because the present batteries have been improved in their performance and have low overpotential resistance. The battery heat capacity was measured by a twin‐type heat conduction calorimeter, and determined to be a linear function of temperature. Further, the heat transfer coefficient was measured again precisely by the method described in our previous study, and was arranged as a function of cell and ambient temperatures. The calculated temperature by our battery thermal behavior model using these measured data agrees well with the cell temperature measured by thermocouple. Therefore, we can confirm the validity of this model again during rapid charge and discharge cycles. © 2006 Wiley Periodicals, Inc. Electr Eng Jpn, 157(3): 17–25, 2006; Published online in Wiley InterScience (www.interscience.wiley.com). DOI 10.1002/eej.20249 Copyright © 2006 Wiley Periodicals, Inc.

Bibliography

Ohshima, T., Nakayama, M., Fukuda, K., Araki, T., & Onda, K. (2006). Thermal behavior of small lithiumâion secondary battery during rapid charge and discharge cycles. Electrical Engineering in Japan, 157(3), 17â25. Portico.

Authors 5

Takamasa Ohshima (first)
Masato Nakayama (additional)
Kenichi Fukuda (additional)
Takuto Araki (additional)
Kazuo Onda (additional)

References 9 Referenced 14

{'key': 'e_1_2_1_2_2', 'first-page': '18', 'volume-title': 'Pictorial energy basics 2001', 'year': '2001'} / Pictorial energy basics 2001 (2001)
{'key': 'e_1_2_1_3_2', 'first-page': '443', 'volume-title': 'Next‐generation lithium‐ion secondary batteries', 'author': 'Tamura H', 'year': '2003'} / Next‐generation lithium‐ion secondary batteries by Tamura H (2003)
{'key': 'e_1_2_1_4_2', 'first-page': '1191', 'article-title': 'Study on heat generation behavior at small lithium‐ion secondary battery', 'volume': '122', 'author': 'Kameyama H', 'year': '2002', 'journal-title': 'Trans IEEE Japan'} / Trans IEEE Japan / Study on heat generation behavior at small lithium‐ion secondary battery by Kameyama H (2002)
{'key': 'e_1_2_1_5_2', 'first-page': '257', 'volume-title': 'Handbook of batteries', 'year': '2001'} / Handbook of batteries (2001)
{'key': 'e_1_2_1_6_2', 'first-page': '91', 'volume-title': 'Electrochemistry', 'author': 'Tamamushi R', 'year': '2000'} / Electrochemistry by Tamamushi R (2000)
{'key': 'e_1_2_1_7_2', 'first-page': '817', 'article-title': 'Simulation of electrical characteristics in a large‐capacity lithium secondary battery', 'volume': '60', 'author': 'Takano K', 'year': '1996', 'journal-title': 'Bull Electrotech Lab'} / Bull Electrotech Lab / Simulation of electrical characteristics in a large‐capacity lithium secondary battery by Takano K (1996)
{'key': 'e_1_2_1_8_2', 'first-page': '763', 'article-title': 'Thermal measurement of a lithium secondary battery', 'volume': '60', 'author': 'Saito Y', 'year': '1996', 'journal-title': 'Bull Electrotech Lab'} / Bull Electrotech Lab / Thermal measurement of a lithium secondary battery by Saito Y (1996)
{'key': 'e_1_2_1_9_2', 'first-page': '771', 'article-title': 'Heart generation behavior of a lithium‐ion secondary battery during charge and discharge', 'volume': '60', 'author': 'Saito Y', 'year': '1996', 'journal-title': 'Bull Electrotech Lab'} / Bull Electrotech Lab / Heart generation behavior of a lithium‐ion secondary battery during charge and discharge by Saito Y (1996)
{'key': 'e_1_2_1_10_2', 'first-page': '1417', 'article-title': 'Thermal behavior of nickel‐metal hydryde battery during charge cycle', 'volume': '122', 'author': 'Fujioka Y', 'year': '2002', 'journal-title': 'Trans IEEE Japan'} / Trans IEEE Japan / Thermal behavior of nickel‐metal hydryde battery during charge cycle by Fujioka Y (2002)

Dates

Type	When
Created	19 years ago (Aug. 17, 2006, 3:57 p.m.)
Deposited	1 year, 9 months ago (Nov. 15, 2023, 2:56 p.m.)
Indexed	11 months, 4 weeks ago (Sept. 8, 2024, 7:35 a.m.)
Issued	19 years ago (Aug. 17, 2006)
Published	19 years ago (Aug. 17, 2006)
Published Online	19 years ago (Aug. 17, 2006)
Published Print	18 years, 9 months ago (Nov. 30, 2006)

Funders 0

None

BibTeX

@article{Ohshima_2006, title={Thermal behavior of small lithium‐ion secondary battery during rapid charge and discharge cycles}, volume={157}, ISSN={1520-6416}, url={http://dx.doi.org/10.1002/eej.20249}, DOI={10.1002/eej.20249}, number={3}, journal={Electrical Engineering in Japan}, publisher={Wiley}, author={Ohshima, Takamasa and Nakayama, Masato and Fukuda, Kenichi and Araki, Takuto and Onda, Kazuo}, year={2006}, month=aug, pages={17–25} }

JSON

{
  "indexed": {
    "date-parts": [
      [
        2024,
        9,
        8
      ]
    ],
    "date-time": "2024-09-08T11:35:14Z",
    "timestamp": 1725795314895
  },
  "reference-count": 9,
  "publisher": "Wiley",
  "issue": "3",
  "license": [
    {
      "start": {
        "date-parts": [
          [
            2006,
            8,
            17
          ]
        ],
        "date-time": "2006-08-17T00:00:00Z",
        "timestamp": 1155772800000
      },
      "content-version": "vor",
      "delay-in-days": 0,
      "URL": "http://onlinelibrary.wiley.com/termsAndConditions#vor"
    }
  ],
  "content-domain": {
    "domain": [],
    "crossmark-restriction": false
  },
  "published-print": {
    "date-parts": [
      [
        2006,
        11,
        30
      ]
    ]
  },
  "abstract": "<jats:title>Abstract</jats:title><jats:p>The secondary batteries for an electric vehicle (EV) generate much heat during rapid charge and discharge cycles above the rated condition, when the EV starts quickly consuming the battery power and stops suddenly recovering the inertia energy. During rapid charge and discharge cycles, the cell temperature rises significantly and may exceed the allowable temperature. We calculated the temperature rise of a small lithium\u2010ion secondary battery during rapid charge and discharge cycles using our battery thermal behavior model, and confirmed its validity during discharge cycle at current smaller than the discharge rate of 1C. The heat source factors were measured by the methods described in our previous study, because the present batteries have been improved in their performance and have low overpotential resistance. The battery heat capacity was measured by a twin\u2010type heat conduction calorimeter, and determined to be a linear function of temperature. Further, the heat transfer coefficient was measured again precisely by the method described in our previous study, and was arranged as a function of cell and ambient temperatures. The calculated temperature by our battery thermal behavior model using these measured data agrees well with the cell temperature measured by thermocouple. Therefore, we can confirm the validity of this model again during rapid charge and discharge cycles. \u00a9 2006 Wiley Periodicals, Inc. Electr Eng Jpn, 157(3): 17\u201325, 2006; Published online in Wiley InterScience (<jats:ext-link xmlns:xlink=\"http://www.w3.org/1999/xlink\" xlink:href=\"http://www.interscience.wiley.com\">www.interscience.wiley.com</jats:ext-link>). DOI 10.1002/eej.20249 Copyright \u00a9 2006 Wiley Periodicals, Inc.</jats:p>",
  "DOI": "10.1002/eej.20249",
  "type": "journal-article",
  "created": {
    "date-parts": [
      [
        2006,
        8,
        17
      ]
    ],
    "date-time": "2006-08-17T19:57:32Z",
    "timestamp": 1155844652000
  },
  "page": "17-25",
  "source": "Crossref",
  "is-referenced-by-count": 14,
  "title": "Thermal behavior of small lithium\u2010ion secondary battery during rapid charge and discharge cycles",
  "prefix": "10.1002",
  "volume": "157",
  "author": [
    {
      "given": "Takamasa",
      "family": "Ohshima",
      "sequence": "first",
      "affiliation": []
    },
    {
      "given": "Masato",
      "family": "Nakayama",
      "sequence": "additional",
      "affiliation": []
    },
    {
      "given": "Kenichi",
      "family": "Fukuda",
      "sequence": "additional",
      "affiliation": []
    },
    {
      "given": "Takuto",
      "family": "Araki",
      "sequence": "additional",
      "affiliation": []
    },
    {
      "given": "Kazuo",
      "family": "Onda",
      "sequence": "additional",
      "affiliation": []
    }
  ],
  "member": "311",
  "published-online": {
    "date-parts": [
      [
        2006,
        8,
        17
      ]
    ]
  },
  "reference": [
    {
      "key": "e_1_2_1_2_2",
      "first-page": "18",
      "volume-title": "Pictorial energy basics 2001",
      "year": "2001"
    },
    {
      "key": "e_1_2_1_3_2",
      "first-page": "443",
      "volume-title": "Next\u2010generation lithium\u2010ion secondary batteries",
      "author": "Tamura H",
      "year": "2003"
    },
    {
      "key": "e_1_2_1_4_2",
      "first-page": "1191",
      "article-title": "Study on heat generation behavior at small lithium\u2010ion secondary battery",
      "volume": "122",
      "author": "Kameyama H",
      "year": "2002",
      "journal-title": "Trans IEEE Japan"
    },
    {
      "key": "e_1_2_1_5_2",
      "first-page": "257",
      "volume-title": "Handbook of batteries",
      "year": "2001"
    },
    {
      "key": "e_1_2_1_6_2",
      "first-page": "91",
      "volume-title": "Electrochemistry",
      "author": "Tamamushi R",
      "year": "2000"
    },
    {
      "key": "e_1_2_1_7_2",
      "first-page": "817",
      "article-title": "Simulation of electrical characteristics in a large\u2010capacity lithium secondary battery",
      "volume": "60",
      "author": "Takano K",
      "year": "1996",
      "journal-title": "Bull Electrotech Lab"
    },
    {
      "key": "e_1_2_1_8_2",
      "first-page": "763",
      "article-title": "Thermal measurement of a lithium secondary battery",
      "volume": "60",
      "author": "Saito Y",
      "year": "1996",
      "journal-title": "Bull Electrotech Lab"
    },
    {
      "key": "e_1_2_1_9_2",
      "first-page": "771",
      "article-title": "Heart generation behavior of a lithium\u2010ion secondary battery during charge and discharge",
      "volume": "60",
      "author": "Saito Y",
      "year": "1996",
      "journal-title": "Bull Electrotech Lab"
    },
    {
      "key": "e_1_2_1_10_2",
      "first-page": "1417",
      "article-title": "Thermal behavior of nickel\u2010metal hydryde battery during charge cycle",
      "volume": "122",
      "author": "Fujioka Y",
      "year": "2002",
      "journal-title": "Trans IEEE Japan"
    }
  ],
  "container-title": "Electrical Engineering in Japan",
  "original-title": [],
  "language": "en",
  "link": [
    {
      "URL": "https://api.wiley.com/onlinelibrary/tdm/v1/articles/10.1002%2Feej.20249",
      "content-type": "unspecified",
      "content-version": "vor",
      "intended-application": "text-mining"
    },
    {
      "URL": "https://onlinelibrary.wiley.com/doi/pdf/10.1002/eej.20249",
      "content-type": "unspecified",
      "content-version": "vor",
      "intended-application": "similarity-checking"
    }
  ],
  "deposited": {
    "date-parts": [
      [
        2023,
        11,
        15
      ]
    ],
    "date-time": "2023-11-15T19:56:04Z",
    "timestamp": 1700078164000
  },
  "score": 1,
  "resource": {
    "primary": {
      "URL": "https://onlinelibrary.wiley.com/doi/10.1002/eej.20249"
    }
  },
  "subtitle": [],
  "short-title": [],
  "issued": {
    "date-parts": [
      [
        2006,
        8,
        17
      ]
    ]
  },
  "references-count": 9,
  "journal-issue": {
    "issue": "3",
    "published-print": {
      "date-parts": [
        [
          2006,
          11,
          30
        ]
      ]
    }
  },
  "alternative-id": [
    "10.1002/eej.20249"
  ],
  "URL": "http://dx.doi.org/10.1002/eej.20249",
  "relation": {},
  "ISSN": [
    "0424-7760",
    "1520-6416"
  ],
  "subject": [],
  "container-title-short": "Electrical Engineering Japan",
  "published": {
    "date-parts": [
      [
        2006,
        8,
        17
      ]
    ]
  }
}